Mitsubishi Montero (1991+). Manual — part 56
Maximum Refinish Diameter . . . . . . 10.1 (257)
Wheel Cylinder Diameter
Montero . . . . . . . . ... .875 (22.22)
Pickup & Ram-50
2WD . . . . . . . . . . .937 (23.80)
4WD . . . . . . . . . . .875 (22.22)
Discard Diameter . . . . . . ... 10.12 (257.0)
(1) - Information is not available.
TORQUE SPECIFICATIONS
TORQUE SPECIFICATIONS TABLE
Application Ft. Lbs. (N.m)
Caliper Guide or Lock Pin Bolt
Guide Pin Bolt . . . . . . ... 29-36 (40-49)
Lock Pin Bolt . . . . . . . 23-30 (31-41)
Caliper Mounting Bolts . . . . . . 58-72 (79-98)
Front Wheel Bearing Nut . . . . . . . .. ( 1)
Rotor-To-Hub Bolts Or Nuts
Pickup (2WD) . . . . . . . 34-38 (46-52)
All Others . . . . . . . ... 36-43 (49-58)
INCH Lbs. (N.m)
Master Cylinder-To-Power Brake Unit Nut . 72-108 (8-12)
(1) - See FRONT BRAKE ROTOR under REMOVAL & INSTALLATION.
COMPUTER RELEARN PROCEDURES
1991 Mitsubishi Montero
GENERAL INFORMATION
Computer Relearn Procedures
All Models
* PLEASE READ THIS FIRST *
The following general procedures are to be used if
driveability problems are encountered after power loss or battery has
been disconnected. These procedures may provide an aid in eliminating
these problems.
To reduce the possibility of complaints, after any service
which requires battery power to be disconnected, vehicle should be
road tested.
COMPUTER RELEARN PROCEDURES
Vehicles equipped with engine or transmission computers may
require a relearn procedure after vehicle battery is disconnected.
Many vehicle computers memorize and store vehicle operation patterns
for optimum driveability and performance. When vehicle battery is
disconnected, this memory is lost. The computer will use default data
until new data from each key start is stored. As computer memorizes
vehicle operation for each new key start, driveability is restored.
Vehicle computers may memorize vehicles operation patterns for 40 of
more key starts.
Customers often complain of driveability problems during
relearn stage because vehicle acts differently then before being
serviced. Depending on type and make of vehicle and how it is
equipped, the following complaints (driveability problems) may exist:
* Harsh Or Poor Shift Quality
* Rough Or Unstable Idle
* Hesitation Or Stumble
* Rich Or Lean Running
* Poor Fuel Mileage
These symptoms and complaints should disappear after a number
of drive cycles have been memorized. To reduce the possibility of
complaints, after any service which requires battery power to be
disconnected, vehicle should be road tested. If a specific relearn
procedure is not available, the following procedure may be used:
Automatic Transmission
* Set parking brake, start engine in "P" or "N" position.
Warm-up vehicle to normal operating temperature or until
cooling fan cycles.
* Allow vehicle to idle for one minute in "N" position. Select
"D" and allow engine to idle for one minute.
* Accelerate at normal throttle position (20-50%) until vehicle
shifts into top gear.
* Cruise at light to medium throttle.
* Decelerate to a stop, allowing vehicle to downshift, and use
brakes normally.
* Process may be repeated as necessary.
Manual Transmission
* Place transmission in Neutral position.
* Ensure emergency brake has been set and all accessories
are turned off.
* Start engine and bring to normal operating temperature.
* Allow vehicle to idle in Neutral for one minute.
* Initial relearn is complete: process will be completed during
normal driving.
Some manufacturers identify a specific relearn procedure
which will help establish suitable driveability during relearn stage.
These procedures are especially important if vehicle is equipped with
and electronically controlled automatic transmission or transaxle.
Always complete procedure before returning vehicle to customer.
COOLING SYSTEM SPECIFICATIONS
1991 Mitsubishi Montero
1991 ENGINE COOLING
Mitsubishi Cooling System Specifications
Mitsubishi: Eclipse, Galant, Mirage,
Montero, Pickup, Precis, 3000GT
COOLING SYSTEM SPECIFICATIONS
COOLING SYSTEM SPECIFICATIONS TABLE
Application Specification
Coolant Replacement Interval . . . . 30,000 Miles or 24 Months
Coolant Capacity
(Includes Heater & Reserve Tank)
Eclipse
1.8L . . . . . . . . . . .. 6.6 qts. (6.2L)
2.0L . . . . . . . . . . .. 7.6 qts. (7.2L)
Galant . . . . . . . . . . .. 7.6 qts. (7.2L)
Montero . . . . . . . . . . 10.0 qts. (9.5L)
Pickup
2WD
Automatic Transmission . . . . . ... 6.4 qts. (6.1L)
Manual Transmission . . . . . . .. 6.3 qts. (6.0L)
4WD . . . . . . . . . . ... 8.9 qts. (8.4L)
Precis . . . . . . . . . . .. 5.6 qts. (5.3L)
3000GT . . . . . . . . . . .. 8.8 qts. (8.3L)
Pressure Cap . . . . . . . . . . . . 11-15 psi
Thermostat Opens
Except 3000GT
Starts . . . . . . . . . . . . 190
F (88
C)
Fully Open . . . . . . . . . . 212
F (100
C)
3000GT
Starts . . . . . . . . . . . . 170
F (77
C)
Fully Open . . . . . . . . . . . 190
F (88
C)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст