Opel Frontera UBS. Service manual — part 1862
AIR CONDITIONING 1B – 49
1 6 1 4 1 A
芳
2
5
3
1
1
LHD
3
2c
2b
2b
(6VD1)
(4JG
*)
3
4
6
7
6
7
7
6
5
3
3
3
4
4
RHD
REFRIGERANT LINE
852RY00009
1B – 50 AIR CONDITIONING
Removal Steps
1. Radiator grille
2. Air cleaner
2a. Dust
2b. Battery and reserver tank
2c. Air cleaner cover
3. Clip and clamp
4. Liquid line (High-pressure pipe)
5. Suction line (Low-pressure pipe)
6. Suction line (Low-pressure hose)
7. Discharge line (High-pressure hose)
Installation Steps
To install, follow the removal steps in the
reverse order.
REMOVAL
Preparation:
•
Disconnect the battery ground cable
•
Discharge and recover refrigerant (Refer to
“REFRIGERANT RECOVERY” in this section.)
1. Radiator Grille
2. Air Cleaner
2a. Duct
2b. Battery and Reserver Tank
2c. Air Cleaner Cover
3. Clip and Clamp
4. Liquid Line (High-pressure pipe)
5. Suction Line (Low-pressure pipe)
6. Suction Line (Low-pressure hose)
7. Discharge Line (High-pressure hose)
•
Use a back-up wrench when disconnecting and
reconnecting the refrigerant lines.
•
When removing the refrigerant line connecting
part, the connecting part should immediately be
plugged or capped to prevent foreign matter from
being mixed into the line.
INSTALLATION
To install, follow the removal steps in the reverse order,
noting the following points:
1. O-rings cannot be reused. Always replace new ones.
2. Be sure to apply compressor oil to the O-rings when
connecting refrigerant lines.
3. Tighten the refrigerant line to the specified torque.
(Refer to “SERVICE INFORMATION” for FIXING
TORQUE in section 00.)
AIR CONDITIONING 1B – 51
REAR COOLER PARTS
5
6
7
8
13
4
9
14
2
12
11
10
3
1
Legend
(1)
Liquid Line (high pressure pipe)
(2)
Cooling Unit
(3)
Suction Line (low pressure pipe)
(4)
Duct Assembly
(5)
Duct Assembly
(6)
Switch
(7)
Knob
(8)
Panel
(9)
Resistor
(10)
Drain Hose
(11)
Cover Assembly
(12)
Filter
(13)
Wire Harness
(14)
Grille Assembly
855RY00002
1B – 52 AIR CONDITIONING
REAR COOLER PARTS (ROOF DUCT TYPE)
16
15
14
2
3
4
5
7
6
1
13
11
12
10
9
8
Legend
(1)
Roof Duct Bracket
(2)
Roof Duct
(3)
Lower Duct
(4)
Resistor
(5)
Wire Harness
(6)
Liquid Line (high pressure pipe)
(7)
Suction Line (low pressure pipe)
(8)
Drain Hose
(9)
Cover Assembly
(10)
Filter
(11)
Cooling Unit
(12)
Grille Assembly
(13)
Panel
(14)
Knob
(15)
Nut
(16)
Fan Control Switch
855RY00001
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст