Infiniti M35/M45 Y50. Manual — part 742

SERVICE DATA AND SPECIFICATIONS (SDS)

EC-1441

[VK45DE]

C

D

E

F

G

H

I

J

K

L

M

A

EC

Heated Oxygen Sensor 2 Heater

NBS005R3

Throttle Control Motor

NBS005R4

Fuel Injector

NBS005R5

Fuel Pump

NBS005R6

Resistance [at 25

°

C (77

°

F)]

5.0 - 7.0

Ω

Resistance [at 25

°

C (77

°

F)]

Approximately 1 - 15

Ω

Resistance [at 10 - 60

°

C (50 - 140

°

F)]

13.5 - 17.5

Ω

Resistance [at 25

°

C (77

°

F)]

0.2 - 5.0

Ω

EC-1442

[VK45DE]

SERVICE DATA AND SPECIFICATIONS (SDS)

EI-1

EXTERIOR & INTERIOR

I BODY

CONTENTS

C

D

E

F

G

H

J

K

L

M

SECTION

EI

A

B

EI

EXTERIOR & INTERIOR

PRECAUTIONS . . . . . . . . . . . . . . .. 3

Precautions for Supplemental Restraint System
(SRS) “AIR BAG” and “SEAT BELT PRE-TEN-
SIONER” . . . . . . . . . . . . . . . . .. 3
Precautions for Procedures without Cowl Top Cover

. . 3

Precautions for Work . . . . . . . . . . . . 3

PREPARATION . . . . . . . . . . . . . . ... 4

Special Service Tools . . . . . . . . . . . ... 4
Commercial Service Tools . . . . . . . . . . 4

SQUEAK AND RATTLE TROUBLE DIAGNOSES . . 5

Work Flow . . . . . . . . . . . . . . . . 5

CUSTOMER INTERVIEW . . . . . . . . . . 5
DUPLICATE THE NOISE AND TEST DRIVE . ... 6
CHECK RELATED SERVICE BULLETINS . . ... 6
LOCATE THE NOISE AND IDENTIFY THE
ROOT CAUSE . . . . . . . . . . . . . .. 6
REPAIR THE CAUSE . . . . . . . . . . ... 6
CONFIRM THE REPAIR . . . . . . . . . ... 7

Generic Squeak and Rattle Troubleshooting . . ... 7

INSTRUMENT PANEL . . . . . . . . . . .. 7
CENTER CONSOLE . . . . . . . . . . . . 7
DOORS . . . . . . . . . . . . . . . . . 7
TRUNK . . . . . . . . . . . . . . . . .. 8
SUNROOF/HEADLINING . . . . . . . . . . 8
SEATS . . . . . . . . . . . . . . . . ... 8
UNDERHOOD . . . . . . . . . . . . . ... 8

Diagnostic Worksheet . . . . . . . . . . . .. 9

FRONT BUMPER . . . . . . . . . . . . . ..11

Removal and Installation . . . . . . . . . . .11

REMOVAL . . . . . . . . . . . . . . ... 12
INSTALLATION . . . . . . . . . . . . ... 12

Removal and Installation of Front Bumper Grille ... 13

REMOVAL . . . . . . . . . . . . . . ... 13
INSTALLATION . . . . . . . . . . . . ... 13

REAR BUMPER . . . . . . . . . . . . . ... 14

Removal and Installation . . . . . . . . . . 14

REMOVAL . . . . . . . . . . . . . . ... 15
INSTALLATION . . . . . . . . . . . . ... 15

FRONT GRILLE . . . . . . . . . . . . . . 16

Removal and Installation . . . . . . . . . . 16

REMOVAL . . . . . . . . . . . . . . ... 16
INSTALLATION . . . . . . . . . . . . ... 16

HOOD . . . . . . . . . . . . . . . . . . 17

Removal and Installation . . . . . . . . . . 17

HOOD TOP MOLDING . . . . . . . . . . 17

COWL TOP . . . . . . . . . . . . . . . ... 18

Removal and Installation . . . . . . . . . . 18

REMOVAL . . . . . . . . . . . . . . ... 18
INSTALLATION . . . . . . . . . . . . ... 18

FENDER PROTECTOR . . . . . . . . . . . 20

Removal and Installation . . . . . . . . . . 20

REMOVAL . . . . . . . . . . . . . . ... 20
INSTALLATION . . . . . . . . . . . . ... 20

Rear Wheel House Protector . . . . . . . . .. 21

REMOVAL AND INSTALLATION . . . . . . 21
REMOVAL . . . . . . . . . . . . . . ... 21
INSTALLATION . . . . . . . . . . . . ... 21

CENTER MUD GUARD . . . . . . . . . . . 22

Removal and Installation . . . . . . . . . . 22

REMOVAL . . . . . . . . . . . . . . ... 22
INSTALLATION . . . . . . . . . . . . ... 22

FLOOR SIDE FAIRING . . . . . . . . . . . . 23

Removal and Installation of Under Cover (for V6
Engine Models) . . . . . . . . . . . . . ... 23
Removal and Installation of Under Cover (for V8
Engine Models) . . . . . . . . . . . . . ... 23

FRONT UNDER COVER . . . . . . . . . 23
FRONT UNDER COVER (REAR) . . . . . ... 24
FLOOR UNDER COVER . . . . . . . . . 24
REAR UNDER COVER . . . . . . . . . ... 24
REAR DIFFUSER . . . . . . . . . . . ... 24

ROOF SIDE MOLDING . . . . . . . . . . . . 25

Removal and Installation . . . . . . . . . . 25

REMOVAL . . . . . . . . . . . . . . ... 25
INSTALLATION . . . . . . . . . . . . ... 26

EI-2

DOOR SASH MOLDING . . . . . . . . . . ... 27

Removal and Installation . . . . . . . . . . 27

FRONT DOOR SASH MOLDING . . . . . . 27
REAR DOOR SUSH MOLDING . . . . . . .. 27
DOOR SASH OUTER COVER . . . . . . . 28
REAR DOOR CORNER COVER . . . . . . 28

DOOR OUTSIDE MOLDING . . . . . . . . . . 29

Removal and Installation . . . . . . . . . . 29

FRONT DOOR OUTSIDE MOLDING . . . . .. 29
REAR DOOR OUTSIDE MOLDING . . . . . 30

SIDE GUARD MOLDING . . . . . . . . . . .. 31

Removal and Installation . . . . . . . . . . 31

REMOVAL . . . . . . . . . . . . . . ... 31
INSTALLATION . . . . . . . . . . . . . 31

DOOR PARTING SEAL . . . . . . . . . . . 32

Removal and Installation . . . . . . . . . . 32

FRONT DOOR PARTING SEAL . . . . . . .. 32
REAR DOOR PARTING SEAL . . . . . . . 32

TRUNK LID FINISHER . . . . . . . . . . . .. 33

Removal and Installation . . . . . . . . . . 33

REMOVAL . . . . . . . . . . . . . . ... 33
INSTALLATION . . . . . . . . . . . . . 33

DOOR FINISHER . . . . . . . . . . . . . .. 34

Removal and Installation . . . . . . . . . . 34

FRONT AND REAR DOOR FINISHER . . . ... 34
FRONT DOOR SASH COVER INNER . . . . 36
REAR DOOR SASH COVER INNER . . . . .. 36

BODY SIDE TRIM . . . . . . . . . . . . . .37

Removal and Installation . . . . . . . . . . .37

FRONT PILLAR GARNISH . . . . . . . . ..38
FRONT KICKING PLATE OUTER . . . . . ...38
FRONT KICKING PLATE INNER . . . . . . 38
FRONT BODY SIDE WELT . . . . . . . . .39
CENTER PILLAR LOWER GARNISH . . . . .39
CENTER PILLAR UPPER GARNISH . . . . ..39
REAR KICKING PLATE OUTER . . . . . . .40
REAR KICKING PLATE INNER . . . . . . ...40
REAR BODY SIDE WELT . . . . . . . . . 40
REAR WHEEL HOUSE GARNISH . . . . . ..41
REAR PILLAR FINISHER . . . . . . . . . 41

REAR PARCEL SHELF FINISHER . . . . . . ...42

Removal and Installation . . . . . . . . . . .42

REMOVAL . . . . . . . . . . . . . . . 42
INSTALLATION . . . . . . . . . . . . . 43

Rear Window Sunshade . . . . . . . . . . .43

REMOVAL AND INSTALLATION . . . . . . .43

SUNSHADE . . . . . . . . . . . . . . . ...44

Component Parts and Harness Connector Location ...44
Schematic . . . . . . . . . . . . . . . ...45
Wiring Diagram—SHADE— . . . . . . . . . 46
Terminals and Reference Values for Rear Sun-
shade Unit . . . . . . . . . . . . . . . ...49

FLOOR TRIM . . . . . . . . . . . . . . . .50

Removal and Installation . . . . . . . . . . .50

REMOVAL . . . . . . . . . . . . . . . 50
INSTALLATION . . . . . . . . . . . . . 51

HEADLINING . . . . . . . . . . . . . . . .52

Removal and Installation . . . . . . . . . . .52

REMOVAL . . . . . . . . . . . . . . . 53
INSTALLATION . . . . . . . . . . . . . 55

TRUNK ROOM TRIM & TRUNK LID FINISHER . ...56

Removal and Installation for Trunk Room Trim . ...56

REMOVAL . . . . . . . . . . . . . . . 57
INSTALLATION . . . . . . . . . . . . . 57
REMOVAL AND INSTALLATION OF TRUNK LID
FINISHER INNER . . . . . . . . . . . . 57