Mitsubishi Montero (1991+). Manual — part 169

federal law. Warranty period is 5 years or 50,000 miles, whichever

occurs first. Covers remedy of non-conformity if vehicle fails to pass

an EPA approved emissions test during the first 24 months or 24,000

miles of this warranty. During the remainder of the warranty period,

covers remedy of non-conformity resulting from failure of certain

emission-related components. See copy of warranty for specific

components covered.

EMISSION SYSTEM WARRANTY (CALIFORNIA)

Warrants that the vehicle was designed, built and equipped to

conform at the time of sale with all applicable U.S. and California

emission standards, and that the emission control system is free from

defects in materials or workmanship which would cause the vehicle not

to meet these standards for 5 years or 50,000 miles, whichever occurs

first. On 1990 and later models, warranty coverage is 3 years or 50,

000 miles, whichever occurs first, with certain emission-related

components covered for 7 years or 70,000 miles, whichever occurs

first. See copy of warranty for specific components covered.

FUSES & CIRCUIT BREAKERS

FUSE PANEL LOCATION

The electrical system is protected against shorts by fuses

that are designed to fail, to prevent damage to the wire harness. The

fuse block is located under the instrument panel on the driver’s side.

If a fuse is blown, locate the cause before replacing the fuse. Spare

fuses are contained in the fuse block.

FUSE PANEL IDENTIFICATION (1983-91)

Fig. 8: Fuse Panel Identification (1983-91)

Courtesy of Mitsubishi Motor Sales of America, Inc.

Fuse & Circuit Breaker Identification

1 - 20 Amp (Yellow)

Hazard Light, Dome Light, Clock

2 - 10 Amp (Red)

Taillights

3 - 10 Amp (Red)

Turn Signal Lights

4 - 10 Amp (Red)

Back-Up Lights, Gauges

5 - 15 Amp (Light Blue)

Defogger

6 - 20 Amp (Yellow)

Heater

7 - 15 Amp (Light Blue)

Stoplights

8 - 15 Amp (Light Blue)

Horn, Wiper, Washer

9 - 10 Amp (Red)

Rear Wiper, Rear Washer

10 - 15 Amp (Light Blue)

Cigarette Lighter, Radio

FUSE PANEL IDENTIFICATION (1992-96)

Fig. 9: Fuse Panel Identification (1992-96)

Courtesy of Mitsubishi Motor Sales of America, Inc.

Fuse & Circuit Breaker Identification

1 - 20 Amp

Not Used

2 - Not Used

10 Amp (1994-96)

ELC-4 A/T Control Module, Cruise Control Unit

3 - 10 Amp

Blower Motor Relay, Headlight Washer Relay, Defogger Relay,

Car Telephone (1992-93)

4 - 10 Amp

Radio Clock, Accessory Socket Relay,

Cruise Control Unit (1994-96), Data Link Connector (1994-96)

5 - 15 Amp

Remote Controlled Mirror, Cigarette Lighter

Accessory Socket Relay (1992-93)

6 - 15 Amp

Door Lock Relay, Door Lock Control Unit (1994-96)

7 - 10 Amp

Overdrive Relay, Variable Shock Absorber Control Unit,

4WD Indicator Control Unit, ABS Power Relay (1992-93),

ABS Control Unit (1994-96), Combination Meter (1994-96)

8 - 10 Amp

Power Window Relay

9 - 15 Amp

Wiper, Washer, Sunroof

10 - 10 Amp

Horn, Cruise Control Unit (1992-93)

11 - 10 Amp

Combination Meter, Multi-meter, Motor Antenna Control Unit,

Buzzer Assembly

12 - 15 Amp

Turn Signal Light, Hazard Light, SRS Diagnosis Unit

13 - 10 Amp

Not Used

14 - 15 Amp

Accessory Socket

15 - Not Used

16 - 25 Amp

Blower Motor

17 - 15 Amp

Stoplight

18 - 10 Amp

Back-up Light, Rear Differential Lock Control Unit

19 - 10 Amp

Engine Control Module, Dome Light, Reading Light,

Cargo Light, Combination Meter, Clock, Door Lock Relay,

Cruise Control Unit, Car Telephone (1992-93)

ELC-4 A/T Control Module (1994-96), Ignition Key Illumination

Light Timer (1994-96)

MAINTENANCE REMINDER LIGHT RESET PROCEDURES

1991 Mitsubishi Montero

1983-96 MAINTENANCE

Chrysler Motors/Mitsubishi Maintenance Reminder Lights

Dodge; Challenger, Colt, Colt Vista, Conquest, Raider,

Ram-50

Eagle; Summit, Summit Wagon

Plymouth; Colt, Colt Vista, Sapporo

Mitsubishi; 3000GT, Cordia, Diamante, Eclipse,

Expo/Expo LRV, Galant, Mirage, Montero, Pickup, Precis,

Sigma, Starion, Tredia, Van/Wagon

EGR/MAINTENANCE REQUIRED WARNING LIGHT

1) On some models, an EGR or MAINTENANCE REQUIRED warning

light in dash will come on as a reminder to have EGR system serviced

(each 50,000 miles), oxygen sensor replaced (each 80,000 miles) or

evaporative carbon canister replaced (100,000 miles).

2) After servicing or replacing components, reset mileage

counter. On all models except 1987-95 Pickup and 1987-93 Ram-50, reset

switch is located on back of instrument cluster.

3) On 1987-95 Pickup and 1987-93 Ram-50, reset switch is on

lower right corner of instrument cluster, behind instrument cluster

face trim. Slide switch to other side to reset indicator light.

4) Remove warning light bulb after 150,000 mile servicing on

Colt Vista and Wagon. Remove bulb after 120,000 mile servicing on Ram-

50.

Fig. 1: Locating Warning Light Reset Switch (Colt Vista; Colt

Wagon is Similar)

Courtesy of Chrysler Motors.