Mitsubishi Eclipse / Eclipse Spyder (2000-2002). Service and repair manual — part 577
SPECIFICATIONS
TSB Revision
BASIC BRAKE SYSTEM
35A-57
LUBRICANTS
M1351000400076
SEALANT
M1351000500062
ITEMS
SPECIFIED LUBRICANT
Brake fluid
DOT3 or DOT4
Brake piston seal
Repair kit grease
Guide pin boot inner surface
Lock pin boot inner surface
Piston boot mounting grooves
Brake piston boot inner surface
Lock pin bush inner surface
Piston cup surface
Front brake pad and inner shim A contact surface <2.4L ENGINE>
Repair kit grease
Brake grease SAE J310, NLGI
NO.1
Front disc brake inner shim A and inner shim B contact surface <2.4L
ENGINE>
Front brake pad and outer shim A contact surface <2.4L ENGINE>
Front disc brake outer shim A and outer shim B contact surface <2.4L
ENGINE>
Rear brake pad and inner shim A contact surface
Rear disc brake inner shim A and inner shim B contact surface
Rear brake shoe and backing plate contact surface
Auto adjuster assembly
ITEM
SPECIFIED SEALANT
REMARKS
Thread part fitting
3M
TM
AAD Part No. 8663 or equivalent
Semi-drying sealant
NOTES
35B-1
GROUP 35B
CONTENTS
GENERAL DESCRIPTION. . . . . . . . .
ANTI-SKID BRAKING SYSTEM (ABS)
DIAGNOSIS . . . . . . . . . . . . . . . . . . . .
INTRODUCTION TO ANTI-LOCK BRAKE
SYSTEM DIAGNOSIS . . . . . . . . . . . . . . . .
ABS DIAGNOSTIC TROUBLESHOOTING
STRATEGY. . . . . . . . . . . . . . . . . . . . . . . . .
ABS TROUBLE CODE DIAGNOSIS. . . . . .
DIAGNOSTIC TROUBLE CODE CHART . .
DIAGNOSTIC TROUBLE CODE
PROCEDURES. . . . . . . . . . . . . . . . . . . . . .
WHEEL SPEED SENSOR CIRCUIT . . . . .
SYMPTOM CHART. . . . . . . . . . . . . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . . . . .
TECHNICAL DESCRIPTION (COMMENT)
DATA LIST REFERENCE TABLE . . . . . . .
ACTUATOR TEST REFERENCE TABLE. .
CHECK AT ABS-ECU . . . . . . . . . . . . . . . . .
SPECIAL TOOLS. . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE. . . . . . . . . . .
BLEEDING . . . . . . . . . . . . . . . . . . . . . . . . .
WHEEL SPEED SENSOR OUTPUT
VOLTAGE MEASUREMENT. . . . . . . . . . . .
HYDRAULIC UNIT CHECK . . . . . . . . . . . . .
DISCHARGED BATTERY . . . . . . . . . . . . . .
MASTER CYLINDER AND
BRAKE BOOSTER . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
MASTER CYLINDER . . . . . . . . . . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
HYDRAULIC UNIT . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
WHEEL SPEED SENSOR . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
SPECIFICATIONS . . . . . . . . . . . . . . .
FASTENER TIGHTENING
SPECIFICATIONS. . . . . . . . . . . . . . . . . . . .
SERVICE SPECIFICATIONS . . . . . . . . . . .
GENERAL DESCRIPTION
TSB Revision
ANTI-LOCK BRAKING SYSTEM (ABS)
35B-2
.
G EN ER A L DESC RIPTIO N
M1352000100089
The ABS consists of components such as the wheel
speed sensors, stoplight switch, hydraulic unit
assembly (integrated with ABS-ECU), ABS rotor, and
the ABS warning light. If a problem occurs in the
system, the malfunctioning components can be
identified and the trouble symptoms will be
memorized by the diagnostic function.
In addition, reading of diagnostic trouble codes and
data list and actuator testing are possible by using
the Scan Tool.
If the ABS hydraulic unit is faulty, the ABS-ECU must
be replaced.
The ABS-ECU runs a self-check for 3 seconds upon
start-up (also ignition switch ON, engine stopped).
The ABS warning light, TCL warning light, and TCL
indicator light should be illuminated during the self-
check and turn off when the self-check completes.
CONSTRUCTION DIAGRAM
ITEMS
SPECIFICATIONS
ABS type
4-sensor, 3-channel type
Speed sensor
Magnet coil type on 4-wheels
Front ABS rotor teeth
43
Rear ABS rotor teeth
43
AC004346 AB
1
2
3
4
5
6
5
6
1. HYDRAULIC UNIT (INTEGRATED
WITH ABS-ECU)
2. STOPLIGHT SWITCH
3. DATA LINK CONNECTOR
4. ABS WARNING LIGHT
5. ABS ROTOR
6. WHEEL SPEED SENSOR
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст