Mitsubishi Colt Ralliart. Manual — part 213
![](/vehicles/winoney/ama/flend/alal.png)
TROUBLESHOOTING
WHEEL AND TYRE
31-7
WHEEL BALANCER CALIBRATION
CHECKING FLOW CHART
AC502720AB
Balance wheel.
Rotate wheel 1/2 turn.
Imbalance = 5 g or less
Imbalance = more than 5 g
Rebalance wheel.
Rotate wheel 1/4 turn.
Imbalance = 5 g or less
Imbalance = more than 5 g
Verify wheel is properly centred.
Verify cones, cup, and wing nut are clean,
undamaged, and appropriate for wheel.
Make necessary corrections, then recheck
wheel balance.
Attach a 5 g weight to the outer rim.
Is the imbalance 5 ± 2 g at 170 – 190˚ away from the
5 g weight?
YES
NO
Attach a 5 g weight to the inner rim at 180˚ opposite
the weight on the outer rim.
Is the imbalance 5 ± 2 g at 170 – 190˚ away from
both 5 g weights?
YES
NO
Balancer does not require
calibration.
Balancer requires calibration.
Contact balancer manufacturer.
ZERO CALIBRATION
CHECK
STATIC BALANCE
CHECK
DYNAMIC BALANCE
CHECK
Main
Index
Group
TOC
![](/vehicles/winoney/ama/flend/buinik.png)
ON-VEHICLE SERVICE
WHEEL AND TYRE
31-8
ON-VEHICLE SERVICE
TYRE INFLATION PRESSURE CHECK
M1311000900475
NOTE: For information on tyre inflation pressure,
refer to the label attached to the centre pillar on the
driver's side.
TYRE WEAR CHECK
M1311001000538
Measure the tread depth of the tyres.
Minimum limit: 1.6 mm
If the remaining tread depth is less than the minimum
limit, replace the tyre.
NOTE: When the tread depth of the tyres is reduced
to 1.6 mm or less, wear indicators will appear.
WHEEL RUNOUT CHECK
M1311001100524
ACX00651AB
Lateral
Radial
Jack up the vehicle so that the wheels are clear of
the floor. While slowly turning the wheel, measure
wheel runout with a dial indicator.
LIMIT:
Item
Steel wheel
Aluminium
wheel
Radial runout
mm
1.2
1.0
Lateral runout
mm
1.2
1.0
If wheel runout exceeds the limit, replace the wheel.
WHEEL AND TYRE
INSTALLATION SERVICE POINT
M1311001300432
Tighten the wheel nuts to the specified torque.
Tightening torque: 98
± 10 N⋅m
Main
Index
Group
TOC
GROUP 35
SERVICE BRAKES
CONTENTS
ANTI-SKID BRAKING SYSTEM (ABS) . . . . . . . . . . . . . . . . . . .
BASIC BRAKE SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ACTIVE STABILITY CONTROL SYSTEM (ASC). . . . . . . . . . . .
Main
Index
GROUP 35A
BASIC BRAKE
SYSTEM
CONTENTS
GENERAL INFORMATION . . . . . . . .
SERVICE SPECIFICATIONS. . . . . . .
LUBRICANTS . . . . . . . . . . . . . . . . . .
SPECIAL TOOLS. . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE. . . . . . . . . . .
BRAKE PEDAL CHECK AND
ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . .
BRAKE BOOSTER OPERATING TEST . . .
CHECK VALVE OPERATION CHECK . . . .
BLEEDING . . . . . . . . . . . . . . . . . . . . . . . . .
BRAKE FLUID LEVEL SENSOR CHECK. .
DISC BRAKE PAD CHECK AND
REPLACEMENT <EXCEPT FOR
RALLIART VERSION-R> . . . . . . . . . . . . . .
DISC BRAKE PAD CHECK AND
REPLACEMENT <RALLIART
VERSION-R> . . . . . . . . . . . . . . . . . . . . . . .
DISC BRAKE ROTOR CHECK. . . . . . . . . .
BRAKE LINING THICKNESS CHECK . . . .
BRAKE DRUM INSIDE DIAMETER
CHECK . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BRAKE LINING AND BRAKE DRUM
CONTACT CHECK . . . . . . . . . . . . . . . . . . .
BRAKE PEDAL . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION <EXCEPT
FOR RALLIART VERSION-R> . . . . . . . . . .
REMOVAL AND INSTALLATION
<RALLIART VERSION-R> . . . . . . . . . . . . .
INSPECTION <EXCEPT FOR RALLIART
VERSION-R> . . . . . . . . . . . . . . . . . . . . . . .
INSPECTION <RALLIART VERSION-R>. .
MASTER CYLINDER ASSEMBLY
AND BRAKE BOOSTER . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
FRONT DISC BRAKE ASSEMBLY . .
REMOVAL AND INSTALLATION
<14-INCH> . . . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION
<15-INCH (VR-X)> . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION
<15-INCH (RALLIART Version-R)> . . . . . . .
DISASSEMBLY AND REASSEMBLY
<14-INCH> . . . . . . . . . . . . . . . . . . . . . . . . .
DISASSEMBLY AND REASSEMBLY
<15-INCH (VR-X)> . . . . . . . . . . . . . . . . . . .
DISASSEMBLY AND REASSEMBLY
<15-INCH (RALLIART Version-R)> . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
REAR DISC BRAKE ASSEMBLY
<VR-X, RALLIART Version-R> . . . . .
REMOVAL AND INSTALLATION
<VR-X> . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION
<RALLIART VERSION-R> . . . . . . . . . . . . .
DISASSEMBLY AND REASSEMBLY
<VR-X> . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DISASSEMBLY AND REASSEMBLY
<RALLIART VERSION-R> . . . . . . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
REAR DRUM BRAKE <LS, VR> . . . .
REAR DRUM BRAKE REMOVAL AND
INSTALLATION . . . . . . . . . . . . . . . . . . . . . .
WHEEL CYLINDER. . . . . . . . . . . . . . . . . . .
Main
Index
Group
TOC
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст