Kia Carnival (2007 year). Manual — part 249
2007 > 2.7L V6 GASOLINE >
TROUBLESHOOTING
Symptom
Suspect Area
Remedy (See page)
Water leaks from sunroof
Dirt accumulated in drain tube
Clear dirt inside of drain
Clogged drain tube
Blow air into drain to remove dirt
Broken or dislocated drain tube, defective
Or cracked clip
Check tube installation and
Flange contact
Deteriorated roof lid weatherstrip
Replace
Excessive roof lid-to-body clearance and
Improperly fitted weatherstrip
Adjust
Wind noise around sunroof
Loose or deformed deflector, gaps
In body work
Retighten adjust or replace
Sunroof lid makes a noise when
moveing
Foreign particles lodged in guide rail
Check drive cable and guide
Rails for foreign particles
Loose guide rails and lid
Retighten
Motor runs but sunroof does not
move or moves only partially
Foreign particles lodged in guide rail
Check drive cable and guide
Rails for foreign particles
Incorrect engagement of motor pinion
With drive cable
Check for loose motor installation
And damaged pinion
Decrease in motor`s clutch slipping force
Adjust
Increased sunroof sliding resistance
Or interference of sunroof with drive
cables, weatherstrip, etc. due to
maladjustment of sunroof
Adjust or replace
Noise in motor (clutch slipping
Noise from motor when sunroof
Is fully opened or closed is not
An unusual noise
Incorrect engagement of motor pinion
With drive cable
Check pinion installation and
Retighten motor
Worn out or damaged motor pinion bearing
Replace motor assembly
Worn out or deformed drive cable
Replace
Door glass fails to operate
Up and down
Incorrect window glass installation
Adjust position
Damaged or faulty regulator arm or regulator
Correct or replace
Door does not open or close
completely
Incorrect door installation
Adjust position
Defective door check assembly
Correct or replace
Door hinge requires grease
Apply grease
Hood does not open or close
completely
Striker and latch not properly aligned
Adjust
Incorrectly installed hood
Adjust
Incorrect hood bumper height
Adjust
Water leak through windshield
end rear window
Defective seal
Fill with sealant
Defective flange
Correct
2007 > 2.7L V6 GASOLINE >
SPECIFICATIONS
HOOD
Type
Rear hinged, gas lifter type
REAR DOOR
Construction
Regulator system
Locking system
Front hinged, full door construction
X-ARM type
Pin-fork system
FRONT DOOR
Construction
Regulator system
Locking system
Sliding door construction
Wire drum type
Pin-fork system
TAILGATE
Type
Inner hinged, gas lifter type
GLASS
THICKNESS
Windshield glass
Front door glass
Rear door glass
Rear window glass
5mm
4mm
4mm
3.5mm
SEAT BELTS
Front
Rear
3 point type with Emergency Locking Retractor
(E.L.R)
3 point type with Emergency Locking Retractor
(E.L.R)
TIGHTENING TORQUE
Items
N.m
Kgf.m
Lbf.ft
Front and rear doors
Door hinge to body
Door hinge to door
Striker
Glass mounting bolt
Outside handle mounting bolt
Rear channel mounting nut
33.3~41.2
21.6~26.5
6.9~10.8
7.8~11.8
6.9~10.8
7.8~11.8
3.4~4.2
2.2~2.7
0.7~1.1
0.8~1.2
0.7~1.1
0.8~1.2
24.6~30.4
15.9~19.5
5.1~8.0
5.8~8.7
5.1~8.0
5.8~8.7
Tailgate
Tailgate hinge to body
Tailgate hinge to tailgate
Tailgate lift mounting bolt
Key cylinder mounting nut
6.9~8.8
6.9~8.8
6.9~8.8
6.9~10.8
0.7~0.9
0.7~0.9
0.7~0.9
0.7~1.1
5.1~6.5
5.1~6.5
5.1~6.5
5.1~8.0
Hood
Hood hinge to body
Hood hinge to hood
Hood latch to body
21.6~26.5
21.6~26.5
6.9~10.8
2.2~2.7
2.2~2.7
0.7~1.1
15.9~19.5
15.9~19.5
5.1~8.0
Seat
Front seat mounting bolts
Rear seat mounting bolts
43.1~64.7
43.1~64.7
4.4~6.6
4.4~6.6
31.8~47.7
31.8~47.7
Seat belt
Front seat belt height adjuster
Front seat belt buckle
mounting bolt
Front seat belt anchor
mounting bolt
Front seat belt lower anchor
Front seat belt upper anchor
Rear seat belt anchor
attaching bolt
Rear seat belt retractor
mounting bolt
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
39.2~53.9
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
4.0~5.5
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
28.9~39.8
Exterior
Fender
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст