Nissan Primera P12. Manual — part 614
LU-18
[F9Q]
OIL FILTER
OIL FILTER
PFP:15208
Removal and Installation
EBS00S31
REMOVAL
1.
Using an oil filter wrench (special service too), remove oil filter.
CAUTION:
●
Be careful not to get burned when the engine and engine oil
are hot.
●
When removing, prepare a shop cloth to absorb any oil
leakage or spillage.
●
Do not allow engine oil to adhere to the drive belts.
●
Completely wipe off any oil that adhere to the engine and
the vehicle.
INSTALLATION
1.
Remove foreign materials adhering to the oil filter installation surface.
2.
Apply engine oil to the oil seal contact surface of the new oil fil-
ter.
3.
Install the oil filter to oil cooler.
4.
After warming up the engine, check for engine oil leakage.
5.
Check oil level and add engine oil. Refer to
.
MBIB0938E
1.
O-ring
2.
Oil filter
MBIB0939E
SMA010
OIL PUMP
LU-19
[F9Q]
C
D
E
F
G
H
I
J
K
L
M
A
LU
OIL PUMP
PFP:15010
Removal and Installation
EBS00S32
REMOVAL
1.
Remove the following parts.
●
Battery ground cable
●
Undercover
●
RH front wheel
2.
Remove right side splash cover.
3.
Remove drive belt. Refer to
.
4.
Remove oil pan. Refer to
.
5.
Remove front cover. Refer to
.
6.
Remove oil pump drive chain. Refer to
EM-183, "Disassembly The Lower Engine"
.
7.
Remove oil pump assembly.
INSTALLATION
Install in the reverse order of removal paying attention to the following.
Front Cover and Oil Pump
●
Refer to
EM-203, "INSTALLATION OF LOWER ENGINE"
.
MBIB0940E
1.
Oil pump drive chain
2.
Crankshaft sprocket
3.
Oil pump assembly
LU-20
[F9Q]
OIL COOLER
OIL COOLER
PFP:21305
Removal and Installation
EBS00S33
CAUTION:
●
Be careful not to get burned when the engine and engine oil are hot.
●
When removing, prepare a shop cloth to absorb any oil leakage or spillage.
●
Completely wipe off any oil that abhere to the engine and the vehicle.
REMOVAL
1.
Drain engine coolant. Refer to
CO-25, "Changing Engine Coolant"
.
CAUTION:
Perform when engine is cold.
2.
Remove oil filter. Refer to
.
3.
Disconnect oil cooler hoses from oil cooler.
4.
Remove oil cooler.
INSPECTION
Oil Cooler
Check oil cooler for cracks and clogging by blowing through coolant inlet. If necessary, replace oil cooler
assembly.
INSTALLATION
Installation is in reverse order of removal.
●
Confirm that no foreign objects are adhering to the installation planes of the oil cooler and block.
MBIB0941E
1.
Cylinder block
2.
O-ring
3.
Water inlet pipe
4.
Water pipe
5.
Water hose
6.
Oil cooler hose
7.
Connecting bolt
8.
Oil cooler
MA-1
MAINTENANCE
L MAINTENANCE
CONTENTS
C
D
E
F
G
H
I
J
K
M
SECTION
A
B
MA
MAINTENANCE
PREPARATION . . . . . . . . . . . . . . ... 3
Special Service Tools . . . . . . . . . . . ... 3
Commercial Service Tool . . . . . . . . . . . 3
DESCRIPTION . . . . . . . . . . . . . . . 4
Pre-delivery Inspection Items . . . . . . . . ... 4
GENERAL MAINTENANCE . . . . . . . . . ... 6
General Maintenance . . . . . . . . . . . ... 6
PERIODIC MAINTENANCE . . . . . . . . . ... 7
Periodic Maintenance . . . . . . . . . . . ... 7
ENGINE AND EMISSION CONTROL MAINTE-
NANCE (YD DIESEL ENGINE) . . . . . . . . 7
CHASSIS AND BODY MAINTENANCE (YD DIE-
SEL ENGINE) . . . . . . . . . . . . . ... 7
ENGINE AND EMISSION CONTROL MAINTE-
NANCE (F9Q DIESEL ENGINE) . . . . . . ... 8
CHASSIS AND BODY MAINTENANCE (F9Q
ENGINE MODELS) . . . . . . . . . . . ... 9
MAINTENANCE UNDER SEVERE DRIVING
CONDITIONS . . . . . . . . . . . . . . 9
ENGINE AND EMISSION CONTROL MAINTE-
NANCE (YD DIESEL ENGINE) . . . . . . . 11
CHASSIS AND BODY MAINTENANCE (YD DIE-
SEL ENGINE) . . . . . . . . . . . . . ..11
ENGINE AND EMISSION CONTROL MAINTE-
NANCE (F9Q DIESEL ENGINE) . . . . . . . 12
CHASSIS AND BODY MAINTENANCE (F9Q
ENGINE MODELS) . . . . . . . . . . . . 13
MAINTENANCE UNDER SEVERE DRIVING
CONDITIONS . . . . . . . . . . . . . .. 13
RECOMMENDED FLUIDS AND LUBRICANTS . .. 15
Fluids and Lubricants . . . . . . . . . . . . 15
SAE Viscosity Number . . . . . . . . . . ... 16
YD ENGINE . . . . . . . . . . . . . . 16
F9Q ENGINE . . . . . . . . . . . . . .. 16
Engine Coolant Mixture Ratio . . . . . . . . 16
ENGINE MAINTENANCE (YD22DDTI) . . . . . 17
Checking Drive Belts . . . . . . . . . . . .. 17
Changing Engine Coolant . . . . . . . . . .. 17
DRAINING ENGINE COOLANT . . . . . . . 17
REFILLING ENGINE COOLANT . . . . . . 18
FLUSHING COOLING SYSTEM . . . . . . . 18
Checking Cooling System . . . . . . . . . .. 19
CHECKING COOLING SYSTEM HOSES . . ... 19
CHECKING RADIATOR . . . . . . . . . .. 19
CHECKING RADIATOR CAP . . . . . . . .. 19
CHECKING COOLING SYSTEM FOR LEAKS ... 20
Checking Fuel Lines . . . . . . . . . . . ... 20
Changing Fuel Filter . . . . . . . . . . . ... 20
REMOVAL . . . . . . . . . . . . . . ... 20
INSTALLATION . . . . . . . . . . . . ... 21
INSPECTION AFTER INSTALLATION . . . . 21
Changing Air Cleaner Filter . . . . . . . . . 21
VISCOUS PAPER TYPE . . . . . . . . . . 21
Changing Engine Oil . . . . . . . . . . . ... 21
Changing Oil Filter . . . . . . . . . . . . .. 22
REMOVAL . . . . . . . . . . . . . . ... 22
INSTALLATION . . . . . . . . . . . . ... 23
Draining Water . . . . . . . . . . . . . . 24
ENGINE MAINTENANCE (F9Q) . . . . . . . ... 25
Checking Drive Belts . . . . . . . . . . . .. 25
TENSION ADJUSTMENT . . . . . . . . ... 25
Changing Engine Coolant . . . . . . . . . ... 25
DRAINING ENGINE COOLANT . . . . . . .. 25
REFILLING ENGINE COOLANT . . . . . . . 25
FLUSHING COOLING SYSTEM . . . . . . . 26
Checking Cooling System . . . . . . . . . .. 26
CHECKING COOLING SYSTEM HOSES . . ... 26
CHECKING RADIATOR . . . . . . . . . .. 26
Checking Fuel Lines . . . . . . . . . . . ... 27
Changing Fuel Filter . . . . . . . . . . . ... 27
REMOVAL . . . . . . . . . . . . . . ... 27
INSTALLATION . . . . . . . . . . . . ... 27
INSPECTION AFTER INSTALLATION . . . . 28
Changing Air Cleaner Filter . . . . . . . . . 28
REMOVAL . . . . . . . . . . . . . . ... 28
INSTALLATION . . . . . . . . . . . . ... 28
Changing Engine Oil . . . . . . . . . . . ... 28
Changing Oil Filter . . . . . . . . . . . . .. 29
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст