Nissan Altima HL32 Hybrid. Manual — part 180
![](/vehicles/gon/sttello/nita/alla.png)
WATER CONTROL VALVE
CO-23
< ON-VEHICLE REPAIR >
[QR25DE]
C
D
E
F
G
H
I
J
K
L
M
A
CO
N
P
O
INSPECTION AFTER REMOVAL
• Place a thread so that it is caught in the valve of the water control
valve. Immerse fully in a container filled with water. Heat while stir-
ring.
• The valve opening temperature is the temperature at which the
valve opens and the falls from the thread.
• Continue heating. Check the full-open lift amount.
NOTE:
The full-open lift amount standard temperature for the water con-
trol valve is the reference value.
• After checking the full-open lift amount, lower the water tempera-
ture and check the valve closing temperature.
Standard values
INSTALLATION
Installation is in the reverse order of removal.
• Install the engine coolant temperature sensor.
Use Genuine RTV Silicone Sealant or equivalent. Refer to
GI-15, "Recommended Chemical Products
• Install the water control valve with the whole circumference of the flange part fitting securely inside the rub-
ber ring.
• Install the water control valve with the up-mark facing up and the frame center part facing upwards. The
position deviation may be within the range of
±10°.
• Use a new gasket and O-ring for installation.
SLC252B
Water Control Valve
Standard Value
Valve opening temperature
93.5
° - 96.5°C (200° - 206°F)
Full-open lift amount
More than 8 mm / 108
°C (0.315 in / 226° F)
Valve closing temperature
90
°C (194° F) or higher
![](/vehicles/gon/sttello/nita/zay.png)
CO-24
< SERVICE DATA AND SPECIFICATIONS (SDS)
[QR25DE]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Capacity
INFOID:0000000004211297
(US qt, Imp qt)
Thermostat
INFOID:0000000004211298
Water Control Valve
INFOID:0000000004211299
Radiator
INFOID:0000000004211300
Unit: kPa (kg / cm
2
, psi)
Coolant capacity (With reservoir tank at MAX level)
7.7 (8 1/8, 6 3/4)
Valve opening temperature
80.5 - 83.5
°C (177 - 182°F)
Full-open lift amount
More than 8 mm / 95
°C (0.315 in / 203°F)
Valve closing temperature
77
°C (171°F) or higher
Valve opening temperature
93.5 - 96.5
°C (200 - 206°F)
Full-open lift amount
More than 8 mm / 108
°C (0.315 in / 226°F)
Valve closing temperature
90
°C (194°F) or higher
Cap relief pressure
Standard
122 - 152 (1.2 - 1.5, 18 - 22)
Limit
107 (1.1, 16)
Leakage test pressure
157 (1.6, 23)
DEF-1
DRIVER CONTROLS
C
D
E
F
G
H
I
J
K
M
SECTION
DEF
A
B
DEF
N
O
P
CONTENTS
DEFOGGER
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . . ..
Work Flow . . . . . . . . . . . . . . . .....
FUNCTION DIAGNOSIS . . . . . . . ...
REAR WINDOW DEFOGGER SYSTEM . . . .
System Diagram . . . . . . . . . . . . . ....
System Description . . . . . . . . . . . . ...
Component Parts Location . . . . . . . . . ....
Component Description . . . . . . . . . . .....
DIAGNOSIS SYSTEM (BCM) . . . . . . . .
COMMON ITEM . . . . . . . . . . . . . . ...
COMMON ITEM : CONSULT-III Function (BCM -
COMMON ITEM) . . . . . . . . . . . . . ...
REAR WINDOW DEFOGGER . . . . . . . . .....
REAR WINDOW DEFOGGER : CONSULT-III
Function (BCM - REAR DEFOGGER) . . . . . ..
COMPONENT DIAGNOSIS . . . . . . .
REAR WINDOW DEFOGGER SWITCH . . .
Description . . . . . . . . . . . . . . . ..
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
REAR WINDOW DEFOGGER RELAY . . . ..
Description . . . . . . . . . . . . . . . ..
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . .
REAR WINDOW DEFOGGER POWER SUP-
PLY AND GROUND CIRCUIT . . . . . . .
Description . . . . . . . . . . . . . . . ..
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . .
DRIVER SIDE DOOR MIRROR DEFOGGER ...
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
PASSENGER SIDE DOOR MIRROR DEFOG-
GER . . . . . . . . . . . . . . . . ...
Description . . . . . . . . . . . . . . . ...
Component Function Check . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
ECU DIAGNOSIS . . . . . . . . . . .
BCM (BODY CONTROL MODULE) . . . . .
Reference Value . . . . . . . . . . . . . ..
Terminal Layout . . . . . . . . . . . . . ...
Physical Values . . . . . . . . . . . . . ...
Wiring Diagram - Defogger Control System . . .
SYMPTOM DIAGNOSIS . . . . . . . ..
REAR WINDOW DEFOGGER AND DOOR
MIRROR DEFOGGER DO NOT OPERATE. .
Diagnosis Procedure . . . . . . . . . . . ...
REAR WINDOW DEFOGGER DOES NOT
OPERATE BUT BOTH OF DOOR MIRROR
DEFOGGER OPERATE. . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
DRIVER SIDE DOOR MIRROR DEFOGGER
DOES NOT OPERATE. . . . . . . . . . .
DEF-2
PASSENGER SIDE DOOR MIRROR DEFOG-
GER DOES NOT OPERATE. . . . . . . .
Diagnosis Procedure . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . ..
PRECAUTION . . . . . . . . . . . .
PRECAUTIONS . . . . . . . . . . . . .
Supplemental Restraint System (SRS) "AIR BAG"
and "SEAT BELT PRE-TENSIONER" . . . . .
Necessary for Steering Wheel Rotation After Bat-
tery Disconnect . . . . . . . . . . . . . ...
ON-VEHICLE REPAIR . . . . . . . ...
FILAMENT . . . . . . . . . . . . . . .
Inspection and Repair . . . . . . . . . . . .
CONDENSER . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст