Volvo S40 (2012 year). Manual — part 16
11 Specifications
Dimensions and weights
11
284
Towing capacity and towball load
Engine
Maximum weight, braked trailer (kg)
Maximum towball load (kg)
1.6
1200
50
DRIVe
1300
75
D2
1300
75
2.0F
1350
75
2.0
1350
75
others
1500
75
Engine
Maximum weight, unbraked trailer (kg)
Maximum towball load (kg)
1.6, 2.0, 2.0F, D2 and DRIVe
650
50
others
700
50
11 Specifications
Engine specifications
11
285
Overview
NOTE
Not all engines are available in all markets.
Engine
Engine
code
A
Output
(kW/rpm)
Output
(hp/rpm)
Torque (Nm/
rpm)
No. of
cylinders
Bore
(mm)
Stroke
(mm)
Swept
volume
(litres)
Com-
pression
ratio
1.6
B4164S3
74/6000
100/6000
150/4000
4
79
81.4
1.596
11.0:1
2.0F
B4204S4
107/6000
145/6000
185/4500
4
87.5
83.1
1.999
10.8:1
2.0
B4204S3
107/6000
145/6000
185/4500
4
87.5
83.1
1.999
10.8:1
T5
B5254T7
169/5000
230/5000
320/1500 – 5000
5
83
93.2
2.521
9.0:1
DRIVe
D4162T
84/3600
115/3600
270/1750-2500
4
75
88.3
1.560
16.0:1
D2
D4162T
84/3600
115/3600
270/1750-2500
4
75
88.3
1.560
16.0:1
D3
D5204T5
110/3500
150/3500
350/1500-2750
5
81
77
1.984
16.5:1
D4
D5204T
130/3500
177/3500
400/1750-2750
5
81
77
1.984
16.5:1
A
Engine code, component and serial number can be read on the engine, see page 280.
11 Specifications
Engine oil
11
286
Adverse driving conditions
Adverse driving conditions can lead to abnor-
mally high oil temperature or oil consumption.
Below are some examples of adverse driving
conditions.
Check the oil level more frequently for long
journeys:
•
towing a caravan or trailer
•
in mountainous regions
•
at high speeds
•
in temperatures colder than -30 °C or hot-
ter than +40 °C
The above also apply to shorter driving dis-
tances at low temperatures.
Choose a fully synthetic engine oil for adverse
driving conditions. It provides extra protection
for the engine.
Volvo recommends Castrol oil products.
IMPORTANT
In order to fulfil the requirements for the
engine's service intervals all engines are
filled with a specially adapted synthetic
engine oil at the factory. The choice of oil
has been made very carefully with regard to
service life, starting characteristics, fuel
consumption and environmental impact.
An approved engine oil must be used in
order that the recommended service inter-
vals can be applied. Only use a prescribed
grade of oil for both filling and oil change,
otherwise you will risk affecting service life,
starting characteristics, fuel consumption
and environmental impact.
Volvo Car Corporation disclaims all war-
ranty liability if engine oil of the prescribed
grade and viscosity is not used.
Volvo recommends that oil changes are car-
ried out at an authorised Volvo workshop.
11 Specifications
Engine oil
11
287
Engine oil grade
Engine
Engine code
Recommended oil grade
Volume, incl. oil filter
(litres)
1.6
B4164S3
Oil grade: ACEA A5/B5
Viscosity: SAE 5W–30
approx. 4.0
2.0F
B4204S4
approx. 4.3
2.0
B4204S3
approx. 4.3
DRIVe
D4162T
approx. 3.8
D2
D4162T
approx. 3.8
T5
B5254T7
Oil grade: ACEA A5/B5
Viscosity: SAE 0W–30
approx. 5.8
D3
D5204T5
approx. 5.9
D4
D5204T
approx. 5.9
For filling engine oil, see page 218.
11 Specifications
Fluids and lubricants
11
288
Overview
IMPORTANT
The recommended transmission fluid must
be used to prevent damage to the gearbox.
Do not mix with any other transmission fluid.
If the transmission is topped up with a dif-
ferent fluid, contact a workshop nearby for
servicing. Volvo recommends that you con-
tact an authorised Volvo workshop.
Gearbox oil
Manual gearbox
Volume (litres)
Prescribed transmission fluid
IB5
2.1
BOT 130 M
B6
1.6
BOT 350M3
MTX75
1.8
M66
1.9
Automatic gearbox
Volume (litres)
Prescribed transmission fluid
MPS6
7.3
BOT 341
AW55-51
7.7
JWS 3309
TF-80SC
7.0
AW1
11 Specifications
Fluids and lubricants
11
``
289
Fluids
Fluid
System
Volume
(litres)
Recommended oil grade
Coolant
1.6
5.8
Coolant recommended by Volvo mixed with 50% water
A
, see the packaging. The thermostat
starts opening at:
petrol engine (1.6) 82 °C
petrol engines 90 °C
diesel engines 82 °C
diesel engine (D2) 83 °C
2.0 and 2.0F
6.5
T5, automatic
gearbox
7.5
D2 and DRIVe
6.2
D3 and D4
8.5
Refrigerant
Air conditioning
B
R134a (HFC134a)
Oil: PAG
Brake fluid
Brake system
0.6
DOT 4+
Power steer-
ing fluid
Power steering
1.0 – 1.2
WSS M2C204-A or equivalent product with same specifications.
Washer fluid
4-cyl. Petrol/Die-
sel
4.0
Washer fluid recommended by Volvo - with frost protection during cold weather and below
freezing point.
5-cyl. Petrol/Die-
sel
6.5
11 Specifications
Fluids and lubricants
11
290
Fluid
System
Volume
(litres)
Recommended oil grade
Fuel
Petrol: 1.6, 2.0,
2.0F
approx. 55
Petrol: see page 143
Petrol: T5
approx. 62
Diesel: D2 and
DRIVe
approx. 52
Diesel: see page 144
Diesel: D3 and D4
approx. 60
A
Water quality must fulfil the standard STD 1285.1.
B
Refrigerant quantity varies depending on engine variant. Volvo recommends that you contact an authorised Volvo workshop for the correct information.
11 Specifications
Fuel
11
``
291
CO
2
emissions and fuel consumption
A
B
C
2.0F
254 (242
A
)
10.9 (14.8
A
)
137 (135
A
)
5.9 (8.2
A
)
180 (174
A
)
7.7 (10.6
A
)
2.0
251
10.8
133
5.7
176
7.6
T5
315
13.5
151
6.5
211
9.0
DRIVe
112
4.3
92
3.5
99
3.8
D2
137
5.2
101
3.8
114
4.3
D3
183
7.0
106
4.0
134
5.1
D3
201
7.6
119
4.5
149
5.6
D4
183
7.0
106
4.0
134
5.1
D4
201
7.6
119
4.5
149
5.6
A
E85
11 Specifications
Fuel
11
292
: gram/km
: litre/100 km
A = urban driving
B = extra-urban driving
C = combined driving
Fuel consumption and emissions of
carbon dioxide
Fuel consumption and emission values in the
table above are based on specific EU cycles
1
,
that apply to cars with kerb weight in the basic
version and without extra equipment. The car's
weight may increase depending on equipment.
This, as well as how heavily the car is loaded,
increases fuel consumption and carbon diox-
ide emissions.
There are several reasons for increased fuel
consumption compared with the table's val-
ues. Examples of this are:
•
The driver's driving style.
•
If the customer has specified wheels larger
than those fitted as standard on the mod-
el's basic version, then resistance increa-
ses.
•
High speed results in increased wind resis-
tance.
•
Fuel quality, road and traffic conditions,
weather and the condition of the car.
Even a combination of the above-mentioned
examples can result in significantly improved
consumption. For further information, please
refer to the regulations referred to.
Large deviations in fuel consumption may arise
in a comparison with the EU driving cycles
which are used in the certification of the car
and on which the consumption figures in the
table are based.
To bear in mind
Tips that the driver can use in order to reduce
consumption:
•
Drive gently and avoid unnecessary accel-
eration as well as braking too hard.
•
Drive with the correct air pressure in the
tyres and check this regularly - select ECO
tyre pressure for best results, see the tyre
pressure table on page 293.
•
Choice of tyres can affect fuel consump-
tion - seek advice on suitable tyres from a
dealer.
See further information and more advice on
pages 13 and 140.
See page 142 for general information on fuel.
1
Official fuel consumption figures are based on two standardised driving cycles in a laboratory environment ("EU driving cycles") all in accordance with EU Directive 80/1268/EEC (Euro 4), EU Regulation
no 692/2008 (Euro 5) and UN ECE Regulation no 101. The regulations cover the driving cycles for urban driving and extra-urban driving. - Urban driving - the measurement starts with cold starting
the engine. The driving is simulated. - Extra-urban driving - the car is accelerated and braked at speeds between 0-120 km/h. The driving is simulated. - A car with a D2 engine and 6-speed manual
transmission with Start/Stop is started in 2nd gear. - The value for combined driving, which is given in the table, according to legislation, is a combination of urban driving and extra-urban driving.
CO
2
emission - to calculate the carbon dioxide emissions from the two driving cycles, the exhaust gases are collected. These are then analysed and give the value for CO
2
emissions.
11 Specifications
Wheel and tyres, dimensions and pressure
11
``
293
Approved tyre pressures
Engine
Tyre size
Speed (km/h)
Load, 1 - 3 persons
Max. load
Max. load
Front (kPa)
A
Rear (kPa)
Front (kPa)
Rear (kPa)
ECO pressure
B
D2
DRIVe
195/65 R15
0–160
210
210
270
270
270
160+
250
210
280
260
-
205/55 R16
0–160
210
210
250
250
250
160+
250
210
280
260
-
205/50 R17
0–160
220
220
250
250
250
160+
260
220
280
260
-
1.6
2.0
2.0F
195/65 R15
205/55 R16
0–160
210
210
250
250
250
160+
250
210
280
260
-
205/50 R17
215/45 R18
C
0–160
220
220
250
250
250
160+
260
220
280
260
-
T5
205/55 R16
0–160
210
210
250
250
250
160+
260
210
280
260
-
205/50 R17
215/45 R18
0–160
220
220
250
250
250
160+
270
220
290
270
-
11 Specifications
Wheel and tyres, dimensions and pressure
11
294
Engine
Tyre size
Speed (km/h)
Load, 1 - 3 persons
Max. load
Max. load
Front (kPa)
A
Rear (kPa)
Front (kPa)
Rear (kPa)
ECO pressure
B
D3
D4
205/55 R16
205/50 R17
215/45 R18
0–160
230
220
250
250
250
160+
270
220
290
270
-
Temporary Spare Tyre
0–80
420
420
420
420
-
A
In certain countries there is the "bar" unit beside the SI unit "pascal": 1 bar = 100 kPa.
B
Economical driving, see page 194.
C
The 1.6 cannot be specified with this tyre.
NOTE
All engines, tyres or combinations of these
are not always available in all markets.
11 Specifications
Electrical system
11
``
295
General
The car has a voltage-regulated AC alternator.
The electrical system is single-pole and uses
the chassis and engine casing as a conductor.
The battery capacity is dependent upon the
equipment level in the vehicle. If the starter
battery is replaced, therefore, you must ensure
that you switch to a battery with the same
capacity as the original battery (see the label
on the battery).
Battery
Voltage (V)
Cold start capacity,
CCA - Cold Cranking Amperes (A)
Reserve capacity
(minutes)
Capacity (Ah)
12
590
100
60
760
A
120
70
12
700
B
135
80
A
Cars equipped with High Performance audio system.
B
Cars equipped with diesel, keyless drive, Premium Sound audio system, fuel-driven heater or RTI.
Bulbs
Lighting
Output (W)
Type
Dipped beam, halogen
55
H7 LL
Main beam, halogen
55
H9
Extra main beam, Dual Xenon/ABL
55
H7 LL
Front direction indicators, halogen/Dual Xenon
21
PY21W LL
Front direction indicators, ABL
24
PY24W SV
11 Specifications
Electrical system
11
296
*
Option/accessory, for more information, see Introduction.
Lighting
Output (W)
Type
Position/Parking lamps, front (Dual Xenon/halogen), Side marker lamps, front
5
W5W LL
Fog lamps
35
H8
Side direction indicators, door mirrors
5
WY5W LL
Front courtesy lighting
3
T10 Socket W2.1x9.5d
Glovebox lighting
3
T10 Socket W2.1x9.5d
Vanity mirror lighting*
1.2
Socket SV5.5 Length 35 mm
Cargo area lighting
10
Socket SV8.5 Length 38 mm
Number plate lighting
5
C5W LL
Rear direction indicators
21
PY21W LL
Position/Side marker lamps, rear
5
P21/5W LL
Reversing lamp, Rear fog lamp
21
P21W LL
11 Specifications
Type approval
11
297
Remote control key system
Country and
region
A, B, CY, CZ, D, DK,
E, EST, F, FIN, GB,
GR, H, I, IRL, L, LT,
LV, M, NL, P, PL, S,
SK, SLO
Delphi hereby
certifies that this
remote control key
system conforms to
the essential char-
acteristic require-
ments and other rel-
evant regulations of
directive 1999/5/EC.
IS, LI, N, CH
HR
ROK
Delphi 2003-07-15,
Germany R-
LPD1-03-0151
BR
TW
ETC093LPD0155
Certification of the Keyless Drive
system
Siemens VDO Automotive A.G. hereby certifies
that this equipment type 5WK4 8952,
5WK48956, 5WK48812 conforms to the
essential characteristic requirements and other
relevant regulations of Directive 1999/5/EC.
11 Specifications
Symbols in the display
11
298
*
Option/accessory, for more information, see Introduction.
General
There are a variety of different symbols in the
display in the car. The symbols are divided into
warning, indicator and information symbols.
Shown below are the most common symbols
with their meanings and a reference to where
in the manual further information can be found.
For more information on symbols and text
messages, see pages 52 and 56.
- Red warning symbol, illuminates when
a fault has been indicated which could affect
the safety and/or driveability of the car. An
explanatory text is shown on the information
display at the same time.
- Yellow information symbol, illuminates
in combination with text in the information dis-
play, when a deviation in any of the car's sys-
tems has occurred. The yellow symbol infor-
mation can also illuminate in combination with
other symbols.
Symbols in the display
Indicator and warning symbols in the
combined instrument panel
Symbol
Meaning
Page
Warning
19, 30, 52, 55,
159
Information
52, 55, 159,
168, 170
Emissions
system
52, 53
Fault in the
ABS system
53, 54
Rear fog lamp
53
Symbol
Meaning
Page
Stability sys-
tem, DSTC*
53, 167, 168
Engine pre-
heater (diesel)
53
Low level in
fuel tank
53
Indicator
symbol for
trailer
54
Parking brake
applied
54
Airbags - SRS
19, 54
11 Specifications
Symbols in the display
11
``
*
Option/accessory, for more information, see Introduction.
299
Symbol
Meaning
Page
Low oil pres-
sure
52, 54
Seatbelt
reminder
16, 54
Alternator not
charging
54
Fault in brake
system
54, 165
Main beam
indicator
51
Symbol
Meaning
Page
Left direction
indicators
51
Right direc-
tion indicators
51
Other information symbols in the
combined instrument panel
Symbol
Meaning
Page
Rain sensor*
68
Cruise control*
69
Gear shift indicator*
155
Information symbols in the centre
console display
Symbol
Meaning
Page
G021216
Surround sound (only
Premium Sound)
251
G021221
News
255
G021222
Programme types
255
G021223
Regional radio pro-
grammes
256
Audio files
258
Directory in CD disc
258
G021220
Traffic information
255
Phone*
272
Bluetooth
TM
hands-
free*
272
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст