Subaru Legacy III (2000-2003 year). Service manual — part 526
CS-24
CONTROL SYSTEMS
DRIVE SELECT CABLE
D: ADJUSTMENT
1) Set the drive select lever to HI position.
2) Remove the knob.
3) Remove console box. <Ref. to EI-34, REMOV-
AL, Console Box.>
4) Loosen the nut.
5) Make sure transmission is in HI position. If isn't,
pull on cable to put transmission in HI position.
6) Tighten the nut in the location where the cable
end bolt stops naturally.
Tightening torque:
18 N·m (1.8 kgf-m, 13.0 ft-lb)
7) Make sure to move transmission to HI or LO po-
sition by moving the drive select lever. If it doesn't,
readjust cable.
CS-00190
( A )
CS-00104
CS-00104
CS-25
CONTROL SYSTEMS
GENERAL DIAGNOSTIC TABLE
7. General Diagnostic Table
A: INSPECTION
Symptom
Remedy
Starter does not run.
Adjust select cable and inhibitor switch, or inspect circuit.
Back-up light does not light up.
Adjust select cable and inhibitor switch, or inspect circuit.
CS-26
CONTROL SYSTEMS
GENERAL DIAGNOSTIC TABLE
MEMO:
AUTOMATIC TRANSMISSION
AT
Page
General Description . . . . . . . . . . . . . . . . . . . . . 2
Automatic Transmission Fluid . . . . . . . . . . . . . . . . ...30
Differential Gear Oil. . . . . . . . . . . . . . . . . . . . ...31
Road Test. . . . . . . . . . . . . . . . . . . . . . . . ..32
Stall Test . . . . . . . . . . . . . . . . . . . . . . . . ...33
Time Lag Test . . . . . . . . . . . . . . . . . . . . . . ...35
Line Pressure Test . . . . . . . . . . . . . . . . . . . . . 36
Transfer Clutch Pressure Test . . . . . . . . . . . . . . . . ..38
Automatic Transmission Assembly . . . . . . . . . . . . . . ...39
Transmission Mounting System . . . . . . . . . . . . . . . . 46
Extension Case Oil Seal . . . . . . . . . . . . . . . . . . ...48
Inhibitor Switch. . . . . . . . . . . . . . . . . . . . . . ..49
Front Vehicle Speed Sensor . . . . . . . . . . . . . . . . . .54
Rear Vehicle Speed Sensor. . . . . . . . . . . . . . . . . ..58
Torque Converter Turbine Speed Sensor . . . . . . . . . . . . .59
Control Valve Body . . . . . . . . . . . . . . . . . . . . ...60
Shift Solenoids, Duty Solenoids and ATF Temperature Sensor . . . ...67
Transfer Duty Solenoid and Valve Body . . . . . . . . . . . . ...70
ATF Filter . . . . . . . . . . . . . . . . . . . . . . . . ..73
Transmission Control Module (TCM) . . . . . . . . . . . . . . 76
ATF Cooler Pipe and Hose . . . . . . . . . . . . . . . . . ...78
Air Breather Hose. . . . . . . . . . . . . . . . . . . . . ..83
Oil Charger Pipe. . . . . . . . . . . . . . . . . . . . . . 84
Torque Converter Clutch Assembly . . . . . . . . . . . . . . ..85
Extension Case . . . . . . . . . . . . . . . . . . . . . . .86
Transfer Clutch. . . . . . . . . . . . . . . . . . . . . . ..90
Multi-plate Clutch . . . . . . . . . . . . . . . . . . . . . ..97
Rear Drive Shaft. . . . . . . . . . . . . . . . . . . . . . 99
Reduction Driven Gear. . . . . . . . . . . . . . . . . . . 101
Reduction Drive Gear. . . . . . . . . . . . . . . . . . . ..104
Center Differential Carrier . . . . . . . . . . . . . . . . . ...106
Parking Pawl . . . . . . . . . . . . . . . . . . . . . . ...108
Torque Converter Clutch Case . . . . . . . . . . . . . . . ...109
Oil Pump . . . . . . . . . . . . . . . . . . . . . . . . .112
Drive Pinion Shaft . . . . . . . . . . . . . . . . . . . . ...118
Front Differential. . . . . . . . . . . . . . . . . . . . . ..124
High Clutch and Reverse Clutch . . . . . . . . . . . . . . . .130
Planetary Gear and Low Clutch . . . . . . . . . . . . . . . ..136
2-4 Brake. . . . . . . . . . . . . . . . . . . . . . . . .145
One-way Clutch. . . . . . . . . . . . . . . . . . . . . ...150
Low and Reverse Brake. . . . . . . . . . . . . . . . . . ..155
Transmission Control Device . . . . . . . . . . . . . . . . ..158
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст