Subaru BRZ (2012 year). Service manual — part 12
RM-2
Recommended Materials
RECOMMENDED MATERIALS
1. Recommended Materials
A: RECOMMENDED MATERIALS
1. GENERAL
To insure the best performance, always use the specified oil, gasoline, adhesive, sealant, etc. or a substitute
of equivalent quality.
2. FUEL
• Use unleaded gasoline to reduce air pollution, because using leaded gasoline will damage the catalytic
converter.
• Do not use the low quality gasoline, or improper fuel such as diesel fuel, fuel alcohol, or gasoline additive
because they will adversely affect on engine components.
• Always use gasoline that is equivalent to that prescribed in the owner’s manual or that of high octane val-
ue. There is the possibility of damaging or improper operation of the engine and fuel injection system if the
specifications are not observed. Use the prescribed gasoline type to maintain proper vehicle performance.
3. LUBRICANTS
Use the lubricants shown in the table below, or equivalent. See the table below to choose the correct SAE
viscosity.
Lubricant
Recommended materials
API standard
ILSAC standard
Engine oil
Choose oil suitable for the standard
from the right.
SN or SM grade “Resource conserving” or
“Energy conserving”
Those with the above API service labels
GF-5 or GF-4
Those with the above ILSAC certification
mark (Starburst mark)
Manual transmission gear oil
MG gear oil special II or GL-3 standard
—
Rear differential gear oil
Differential gear oil LX or GL-5 standard
—
RM-00076
A
M
E
R
IC
A
N
PE
TROLEUM
IN
S
T
IT
U
T
E
FOR
GASOLINE
ENGINES
C E
R TIF E
I D
RM-00002
RM-3
Recommended Materials
RECOMMENDED MATERIALS
4. FLUID
Use the fluids specified in the table below. Do not mix two different kinds or makes of fluid.
CAUTION:
Always use the recommended ATF for the AT. Using other fluid will cause a malfunction.
SAE viscosity No. and applicable temperature
Engine oil
(1) 0W-20 (synthetic oil) Recommended
Manual transmission gear oil and rear differential gear oil
(1) 75W-85, 75W-90
Fluid
Recommended materials
Item number
Alternative
Automatic transmission fluid
Auto Fluid WS
0888602303
—
Brake fluid and clutch fluid
FMVSS No. 116 DOT3, or DOT4
—
—
(˚F)
–22
–4
14
50
68
86
104
(˚C)
–30
–20
–10
0
10
20
30
40
32
RM-00075
(1)
(˚F)
–22
–4
14
50
68
86
104
(˚C)
–30
–20
–10
0
10
20
30
40
32
RM-00075
(1)
RM-4
Recommended Materials
RECOMMENDED MATERIALS
5. ENGINE COOLANT
Use genuine engine coolant to protect the engine.
6. REFRIGERANT
Standard air conditioners on Subaru vehicles use HFC134a refrigerant. Do not mix it with other refrigerants.
Also, do not use any air compressor oil except for ND-OIL8.
7. GREASE
Use grease and supplementary lubricants shown in the table below.
Engine coolant
Recommended materials
Item number
Alternative
Coolant
SUBARU SUPER COOLANT
(Concentrated type)
—
—
SUBARU SUPER COOLANT
(Diluted type)
K0670Y0001
Water for dilution
Distilled water
—
Soft water or tap water
Cooling system protective
agent
Cooling system conditioner
SOA345001
—
Air Conditioner
Recommended materials
Item number
Alternative
Refrigerant
HFC134a
—
—
Compressor oil
ND-OIL8
—
—
Grease
Application point
Recommended materials
Item number
Alternative
Supplementary
lubricants
Oxygen sensor
Spray type lubricant
—
—
Grease
• MT main shaft (spline parts)
• Clutch release lever
• Clutch release bearing (inner cir-
cumference)
• Clutch operating cylinder
NICHIMOLY N-130
K0879Y0501
—
Clutch master cylinder push rod
SILICONE GREASE G-40M
004404003
—
• Shift lever pin
• Floor shift control shift lever
retainer
• Clutch pedal
• Brake pedal
NIGTIGHT LYW
No. 2 grease
—
—
• Gear shift lever (MT joint parts)
• Floor shift control shaft
Perma Lube CGN-3
—
—
Select lever
Multemp D
—
—
• Door latch
• Door striker
SILICONE GREASE G-30M
004404002
—
Steering gearbox
(rack and pinion)
Multemp AC-P
—
—
Steering gearbox
(Boot and tie-rod installation parts)
Toshiba Silicon TSM 650 or
Idemitsu Autorex A
—
—
Disc brake (lock pin, guide pin, pis-
ton boot)
Brake grease
(NIGLUBE RX-2)
K0779GA102
—
Between front brake pad and shim
Molykote AS-880N
K0777YA010
—
Brake pad clip
Molykote M7439
(Brake Grease 60G)
003602001
—
Rear axle EDJ
NKG814
—
—
Rear axle EBJ
NKG106
—
—
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст