Subaru BRZ (2012 year). Service manual — part 37
PM-77
Differential Gear Oil
PERIODIC MAINTENANCE SERVICES
6) Install the filler plug.
NOTE:
Use a new gasket.
Tightening torque:
49 N·m (5.0 kgf-m, 36.1 ft-lb)
PM-78
Brake Line
PERIODIC MAINTENANCE SERVICES
16.Brake Line
A: INSPECTION
1. BRAKE LINE
1) Check for scratches, swelling, corrosion, traces of fluid leakage on the brake hoses or pipe joints.
2) Make sure that brake pipes/hoses do not interfere with adjacent parts and there is no loose connector/
clamp during driving.
3) Check any trace of fluid leakage, scratches, etc. on master cylinder, wheel cylinder and hydraulic unit.
NOTE:
• When the brake fluid level in the reservoir tank is lower than specified limit, the brake warning light on the
combination meter will illuminate.
• Visually check the brake hose for damage. (Use a mirror where it is difficult to see.)
(A) Front brake hose
(B) Front brake pipe
(C) Clamp
PM-00582
(B)
(A)
(C)
PM-79
Brake Line
PERIODIC MAINTENANCE SERVICES
2. SERVICE BRAKE
1) Move the brake pedal pads in a horizontal direction with a force of approx. 10 N (1 kgf, 2 lbf), and check
that the pedal deflection is in the range of specifications.
CAUTION:
If excessive deflection is noted, replace with a new bushing.
Deflection of brake pedal:
Wear limit: 5.0 mm (0.197 in) or less
(A) Brake pipe
(B) Rear brake hose
(C) Clamp
(a)
Brake pedal (AT model)
(b)
Brake pedal (MT model)
PM-00583
(C)
(A)
(B)
(a)
(b)
BR-00959
PM-80
Brake Line
PERIODIC MAINTENANCE SERVICES
2) Check the position of the pedal pad.
Pedal height L:
AT: 150 mm (5.90 in)
MT: 145 mm (5.71 in)
Brake pedal free play A:
0.5 — 2 mm (0.020 — 0.079 in) [When pulling the brake pedal upward with a force of less than 10 N
(1 kgf, 2 lbf).]
3) If it is not within the specification, loosen the lock nuts of vacuum booster operating rod, and rotate the rod
to adjust the pedal height L within the specification.
4) Tighten the operating lock nut.
Tightening torque:
22 N·m (2.24 kgf-m, 16.2 ft-lb)
NOTE:
Check the brake pedal height. When adjusting, also adjust the switch - stop light.
(a)
Switch - stop light
(c)
Toe board
(d)
Brake booster operating rod
(b)
Mat
(a)
(b)
(c)
(d)
L
A
BR-00960
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст